微反应器中水层对Cu-Zn共沉淀过程的影响

陈鑫超1 凌晨1 蒋新1 陈帅帅1 卢建刚2

(1.浙江大学化学工程与生物工程学院浙江省化工高效制造技术重点实验室, 浙江杭州 310027)
(2.浙江大学控制科学与工程学院工业控制技术国家重点实验室, 浙江杭州 310027)

【摘要】探索了利用扩散反应的耦合制备更均匀的铜锌共沉淀物的方法。通过在微反应器中引入水层并调节水层占总流量的比例, 制得了高催化活性的Cu/Zn O共沉淀催化剂。采用高倍电镜线扫 (HRTEM/EDS) 、X射线衍射 (XRD) 、热重分析 (TG) 、氢气程序升温还原 (H2-TPR) 、N2O化学反应法分析催化剂微结构的差异以及演变关系。结果显示, 水层占比增加, 初始沉淀物Cu-Zn分布更加均匀, 陈化得到的前体中锌含量增大, 焙烧得到的氧化物CuO和Zn O接触面积增加, 相互作用力不断增强, 最终提升了催化剂催化活性。通过模型数值分析发现, Zn2+较快的扩散速率部分抵消了其反应速率慢导致的不均匀性;随着水层占比增加, 形成均匀沉淀的扩散-反应动态平衡区域增加, 产物中均匀沉淀物的比例得以提高。

【关键词】 微反应器; 共沉淀法; 显微结构; 模型; 数值模拟; Cu-Zn分布; 扩散-反应平衡;

【DOI】

【基金资助】 国家重点研发计划项目 (2017YFC0211802) 国家重点研发计划项目 (2017YFC0211802) 国家自然科学基金项目 (21276223, 21676236) 国家自然科学基金项目 (21276223, 21676236)

Download this article

    References

    [1]REICHENBACH T, MONDAL K, JAGER M, et al.Ab initio study of CO2 hydrogenation mechanisms on inverse ZnO/Cu catalysts[J].Journal of Catalysis, 2018, 360:168-174.

    [2]WENZE L, PENG L, DING X, et al.CO2 hydrogenation to methanol over Cu/ZnO catalysts synthesized via a facile solid-phase grinding process using oxalic acid[J].Korean J.Chem.Eng., 2018, 35 (1) :110-117.

    [3]SALEHIRAD A, LATIFI S M.Effect of synthesis method on physicochemical and catalytic properties of Cu-Zn-based mesoporous nanocatalysts for water-gas shift reaction[J].Research on Chemical Intermediates, 2017, 43 (7) :3633-3649.

    [4]JEONG Y, KANG J Y, KIM I, et al.Preparation of Cu/ZnO catalyst using a polyol method for alcohol-assisted low temperature methanol synthesis from syngas[J].Korean J.Chem.Eng., 2016, 33 (1) :114-119.

    [5]CHEN Y P, JIANG X, LU J G.Effects of reaction progress in microchannel on microstructure of Cu-Zn catalyst[J].CIESC Journal, 2015, 66 (10) :3895-3902.

    [6]SHYAM K, PEDRO J R, JINGGUANG G C, et al.Active sites for CO2 hydrogenation to methanol on Cu/ZnO catalysts[J].Science, 2017, 355:1296-1299.

    [7]ZHANG B, CHEN Y, LI J, et al.High efficiency Cu-ZnOhydrogenation catalyst:the tailoring of Cu-ZnO interface sites by molecular layer deposition[J].ACS Catalysis, 2015, 5 (9) :5567-5573.

    [8]KULD S, THORHAUGE M, FALSIG H, et al.Quantifying the promotion of Cu catalysts by ZnO for methanol synthesis[J].Science, 2016, 352 (6288) :969-974.

    [9]ÁLVAREZ G C, SCHUMANN J, BEHRENS M, et al.Reverse watergas shift reaction at the Cu/ZnO interface:influence of the Cu/Zn ratio on structure-activity correlations[J].Applied Catalysis B:Environmental, 2016, 195:104-111.

    [10]BEHRENS M, SCHLÖGL R.How to prepare a good Cu/ZnO catalyst or the role of solid state chemistry for the synthesis of nanostructured catalysts[J].Z.Anorg.Allg.Chem., 2013, 639 (15) :2683-2695.

    [11]BEMS B, SCHUR M, DASSENOY A, et al.Relations between synthesis and microstructural properties of copper/zinc hydroxycarbonates[J].Chemistry-A European Journal, 2003, 9 (9) :2039-2052.

    [12]BEHRENS M, BRENNECKE D, GIRGSDIES F, et al.Understanding the complexity of a catalyst synthesis:co-precipitation of mixed Cu, Zn, Al hydroxycarbonate precursors for Cu/ZnO/Al2O3 catalysts investigated by titration experiments[J].Applied Catalysis A:General, 2011, 392 (1/2) :93-102.

    [13]JIANG X, ZHENG L, LU J G, et al.Microstructure characters of Cu/ZnO catalyst precipitated inside microchannel reactor[J].Journal of Molecular Catalysis A:Chemical, 2016, 423:457-462.

    [14]ANGELO L, GIRLEANU M, ERSEN O, et al.Catalyst synthesis by continuous coprecipitation under micro-fluidic conditions:application to the preparation of catalysts for methanol synthesis from CO2/H2[J].Catalysis Today, 2016, 270:59-67.

    [15]MICHAEL S, BETTINA B, ALINA D, et al.Continuous coprecipitation of catalysts in a micromixer:nanostructured Cu/ZnOcomposite for the synthesis of methanol[J].Angew.Chem.Int.Ed., 2013, 42:3815-3817.

    [16]SIMSON G, PRASETYO E, REINER S, et al.Continuous precipitation of Cu/ZnO/Al2O3 catalysts for methanol synthesis in microstructured reactors with alternative precipitating agents[J].Applied Catalysis A:General, 2013, 450:1-12.

    [17]JIANG X, QIN X F, LING C, et al.The effect of mixing on coprecipitation and evolution of microstructure of Cu-ZnO catalyst[J].AIChE Journal, 2018, 64 (7) :2647-2654.

    [18]LING C, JIANG X, LU J G, et al.Influence of mixing inside microreactor on microstructural evolution of Cu-ZnO catalyst[J].CIESC Journal, 2018, 69 (2) :718-724.

    [19]PAWEŁK, KATARZYNA A-J, WIESŁAW P, et al.The evaluation of synthesis route impact on structure, morphology and LT-WGS activity of Cu/ZnO/Al2O3 catalysts[J].Catal.Lett., 2017, 147:1422-1433.

    [20]ZANDER S, SEIDLHOFER B, BEHRENS M.In situ EDXRD study of the chemistry of aging of co-precipitated mixed Cu, Zn hydroxycarbonates-consequences for the preparation of Cu/ZnOcatalysts[J].Dalton Transactions, 2012, 41 (43) :13413-13422.

    [21]DAVID M W, ALI A M, JUSTIN S J H.Co-precipitated copper zinc oxide catalysts for ambient temperature carbon monoxide oxidation:effect of precipitate ageing on catalyst activity[J].Phys.Chem.Chem.Phys., 2002, 4:5915-5920.

    [22]BALTES C, VUKOJEVI´C S, SCHÜTH F.Correlations between synthesis, precursor, and catalyst structure and activity of a large set of CuO/ZnO/Al2O3 catalysts for methanol synthesis[J].Journal of Catalysis, 2008, 258:334-344.

    [23]LI J L, INUI T.Characterization of precursors of methanol synthesis catalysts, copper/zinc/aluminum oxides, precipitated at different p Hs and temperatures[J].Applied Catalysis A:General, 1996, 137 (1) :105-117.

    [24]WANG D J, TAO F R, ZHAO H H, et al.Preparation of Cu/ZnO/Al2O3catalyst for CO2 hydrogenation to methanol by CO2 assisted aging[J].Chinese Journal of Catalysis, 2011, 32 (9/10) :1452-1456.

    [25]JAMES G S.Lange’s Handbook of Chemistry[M].6th ed.America:Mc Graw-Hill Companies, Inc., 334-352.

    [26]BEHRENS M, GIRGSDIES F.Structural effects of Cu/Zn substitution in the Malachite-Rosasite system[J].Zeitschrift für anorganische und allgemeine Chemie, 2010, 636 (6) :919-927.

    [27]KÜHL S, FRIEDRICH M, ARMBRÜSTER M, et al.Cu, Zn, Al layered double hydroxides as precursors for copper catalysts in methanol steam reforming-pH-controlled synthesis by microemulsion technique[J].Journal of Materials Chemistry, 2012, 22 (19) :9632.

    [28]MIAO S, D'ALNONCOURT R N, REINECKE T, et al.A study of the influence of composition on the microstructural properties of ZnO/Al2O3 mixed oxides[J].European Journal of Inorganic Chemistry, 2009, 2009 (7) :910-921.

    [29]ROBINSON W, MOL J.Support effects in methanol synthesis over copper-containing catalysts[J].Applied Catalysis, 1991, 76:117-129.

    [30]FIERRO G, LO J M, INVERSI M, et al.Study of the reducibility of copper in CuO-ZnO catalysts by temperature-programmed reduction[J].Applied Catalysis A:General, 1996, 137 (2) :327-348.

    [31]LUO G S, WANG K, LÜY C, et al.Research and development of micro-scale multiphase reaction processes[J].CIESC Journal, 2013, 64 (1) :165-172.

    [32]CHEN G W, ZHAO Y C, LE J, et al.Transport phenomena in microchemical engineering[J].CIESC Journal, 2013, 64 (1) :63-75.

This Article

ISSN:0438-1157

CN: 11-1946/TQ

Vol 69, No. 10, Pages 4261-4268

October 2018

Downloads:0

Share
Article Outline

摘要

  • 引言
  • 1 实验材料和方法
  • 2 结果与讨论
  • 3 结论
  • 参考文献